Airworthiness Directives; Airbus Helicopters
Published Date: 2/2/2026
Rule
Summary
If you own or operate an Airbus H160-B helicopter, listen up! The FAA found a serious problem where a key rotor part can break mid-flight, so they’re requiring you to swap out certain pitch rod bearings with new, safer ones by February 17, 2026. This fix keeps flights safe and stops faulty parts from being used again. You’ll also need to report once the replacement is done, and the FAA wants your feedback by March 19, 2026.
Analyzed Economic Effects
4 provisions identified: 0 benefits, 4 costs, 0 mixed.
Mandatory bearing replacement by Feb 17
If you own or operate an Airbus Helicopters Model H160-B, you must replace the upper and lower main rotor pitch rod end bearings with new, serviceable parts. This AD is effective February 17, 2026, and also prohibits installing any affected main rotor lower and upper pitch rod end bearings on any helicopter unless the part is serviceable. The FAA will accept comments on the AD until March 19, 2026.
Substantial per-helicopter compliance cost
The FAA estimates this AD affects 13 U.S.-registered H160-B helicopters. Estimated cost to replace the upper and lower pitch rod end bearings is up to $135,250 per helicopter (labor: 8 work-hours × $85/hour = $680; parts: up to $134,570). The FAA estimates total cost on U.S. operators up to $1,758,250.
Operational limits, TIS threshold, and flight rules
The FAA identified a significant risk for helicopters with affected parts that have exceeded 160 hours time-in-service (TIS). Given the urgency, the FAA permits only one additional flight of maximum duration 5 hours TIS before mandatory replacement of those parts. Separately, the regulatory text states special flight permits are prohibited.
Mandatory reporting and parts return paperwork
After replacing the pitch rod bearings you must report information and return parts as required by the AD. The FAA estimates reporting will take about 1 hour per response (at $85/hour) and return-of-parts paperwork about 1 hour plus roughly $50 shipping (about $135 per replacement cycle). The Paperwork Reduction Act OMB control number for this collection is 2120-0056 and all responses are mandatory.
Your PRIA Score
Personalized for You
How does this regulation affect your finances?
Sign up for a PRIA Policy Scan to see your personalized alignment score for this federal register document and every other regulation we track. We analyze your financial profile against policy provisions to show you exactly what matters to your wallet.
Key Dates
Department and Agencies
Related Federal Register Documents
2026-08943 — Designation-Restrict the Operation of Unmanned Aircraft in Close Proximity to a Fixed Site Facility
The FAA is proposing new rules to keep drones away from certain important fixed sites like power plants or airports to keep everyone safe and secure. If you own or operate one of these sites, you can request a drone flight restriction zone to protect your property and people nearby. Comments are open until July 6, 2026, and these changes could affect drone pilots and site operators, but no big costs are expected.
2026-10293 — Prohibition of Remote Dispatching
The FAA wants to stop airplane dispatchers from working remotely, except in emergencies when the main center is down. This change affects all domestic, flag, and supplemental airline operators and aims to keep flight safety tight and clear. Comments on this rule are open until July 21, 2026, so airlines and dispatchers should get ready for a new way of working that could shake up their routines.
2026-10270 — Airworthiness Directives; Embraer S.A. (Type Certificate Previously Held by Yaborã Indústria Aeronáutica S.A.; Embraer S.A.) Airplanes
The FAA is requiring certain Embraer ERJ 190-100 ECJ airplanes to get a close check on their overheat detection sensors because some parts might not work right. If problems are found, those parts must be replaced, and no faulty parts can be installed anymore. This rule kicks in on June 26, 2026, helping keep flights safe without breaking the bank.
2026-10256 — Airworthiness Directives; Airbus Helicopters
If you fly Airbus EC130T2 helicopters, the FAA wants you to install a new fix on the tail rotor drive shaft and keep checking its vibration regularly. This update replaces old rules and stops certain parts from being used unless they meet new safety standards. You’ve got until July 6, 2026, to share your thoughts, and while this might cost some bucks, it’s all about keeping flights safe and smooth.
2026-10271 — Airworthiness Directives; Bombardier, Inc., Airplanes
The FAA is making sure certain Bombardier BD-700 airplanes are safe by checking and fixing bolts on the baggage door that might have been tightened wrong. Owners need to inspect and adjust or replace these bolts by June 26, 2026, to keep flying safely. This fix helps avoid any door problems and keeps passengers secure without breaking the bank.
2026-10272 — Airworthiness Directives; Airbus SAS Airplanes
If you fly or work with Airbus A330 planes, listen up! The FAA found a problem where a backup fuel pump might fail quietly, trapping fuel that can’t be used. Starting June 8, 2026, airlines must regularly check these pumps and fix any issues to keep flights safe—no big wallet hits expected, just smart safety moves.
Previous / Next Documents
Previous: 2026-01948 — List of Approved Spent Fuel Storage Casks: TN Americas LLC, NUHOMS® EOS Dry Spent Fuel Storage System, Certificate of Compliance No. 1042, Amendment Nos. 3 and 4; Corrections
The Nuclear Regulatory Commission fixed some typos and small errors in the rules for the NUHOMS® EOS Dry Spent Fuel Storage System, which stores used nuclear fuel safely. These fixes update Amendments 3 and 4, which took effect in 2023 and 2025. If you work with or rely on this storage system, these corrections keep everything clear and official starting February 2, 2026—no extra costs or delays involved!
Next: 2026-01956 — Airworthiness Directives; Airbus Helicopters Deutschland GmbH (AHD) Helicopters
If you fly Airbus Helicopters Deutschland EC135 models, listen up! The FAA is updating safety rules to include newer EC135P3 and EC135T3 helicopters and speeding up inspections for cracks in a key ring frame part. You can either keep inspecting or modify the part to stop inspections—this kicks in February 17, 2026, so plan ahead to keep your chopper safe and flying.