Part 219: ORGANIC MATERIAL EMISSION STANDARDS AND LIMITATIONS FOR THE METRO EAST AREA

Section 219.463 Alternative Emission Reduction Systems In lieu of complying with Section 219.461 or 219.462 of this Part, the owner or operator of an source may utilize an alternative volatile organic emission reduction system, including an alternative production process, which i…

Section 219.464 Emission Testing a) Upon a reasonable request by the Agency, the owner or operator of a VOM source required to comply with a limit of Sections 219.461 through 219.464 of this Part shall conduct emissions testing, at such person's own expense, to demonstrate compli…

Section 219.465 Compliance Dates (Repealed) (Source: Repealed at 17 Ill. Reg. 16918, effective September 27, 1993)

Section 219.466 Compliance Plan (Repealed) (Source: Repealed at 17 Ill. Reg. 16918, effective September 27, 1993) SUBPART T: PHARMACEUTICAL MANUFACTURING

Section 219.480 Applicability a) The rules of this Subpart, except for Sections 219.483 through 219.485 of this Part, apply to all emission units of VOM, including but not limited to reactors, distillation units, dryers, storage tanks for VOL, equipment for the transfer of VOL, f…

Section 219.481 Control of Reactors, Distillation Units, Crystallizers, Centrifuges and Vacuum Dryers a) The owner or operator shall equip all reactors, distillation units, crystallizers, centrifuges and vacuum dryers that are used to manufacture pharmaceuticals with surface cond…

Section 219.482 Control of Air Dryers, Production Equipment Exhaust Systems and Filters a) The owner or operator of an air dryer or production equipment exhaust system used to manufacture pharmaceuticals shall control the emissions of VOM from such emission units by air pollution…

Section 219.483 Material Storage and Transfer The owner or operator of a pharmaceutical manufacturing source shall: a) Provide a vapor balance system that is at least 90 percent effective in reducing VOM emissions from truck or railcar deliveries to storage tanks with capacities …

Section 219.484 In-Process Tanks The owner or operator shall install covers on all in-process tanks used to manufacture pharmaceuticals and containing a VOL at any time. These covers must remain closed, except as production, sampling, maintenance or inspection procedures require …

Section 219.485 Leaks The owner or operator of a pharmaceutical manufacturing source shall repair any component from which a leak of VOL can be observed. The repair shall be completed as soon as practicable but no later than 15 days after the leak is found. If the leaking compone…

Section 219.486 Other Emission Units The owner or operator of a washer, laboratory hood, tablet coating operation, mixing operation or any other process emission unit not subject to Section 219.481 through 219.485 of this Part, and used to manufacture pharmaceuticals shall contro…

Section 219.487 Testing a) Upon request by the Agency or the USEPA, the owner or operator of any VOM source subject to this Subpart or exempt from this Subpart by virtue of the provisions of Section 219.480 of this Part shall, at his own expense, demonstrate compliance to the Age…

Section 219.488 Monitoring for Air Pollution Control Equipment a) At a minimum, continuous monitors for the following parameters shall be installed on air pollution control equipment used to control sources subject to this Subpart: 1) Destruction device combustion temperature. 2)…

Section 219.489 Recordkeeping for Air Pollution Control Equipment a) The owner or operator of a pharmaceutical manufacturing source shall maintain the following records: 1) Parameters listed in Section 219.488(a) of this Part shall be recorded. 2) For emission units subject to Se…

Section 219.500 Applicability for Batch Operations a) The control requirements set forth in Section 219.501 of this Subpart shall apply to process vents associated with batch operations at sources identified by any of the following four-digit standard industrial classification ("…

Section 219.501 Control Requirements for Batch Operations a) Every owner or operator of a single unit operation with an average flow rate, as determined in accordance with Section 219.502(b) of this Subpart, below the flow rate value calculated by the applicability equations cont…

Section 219.502 Determination of Uncontrolled Total Annual Mass Emissions and Actual Weighted Average Flow Rate Values for Batch Operations a) Uncontrolled total annual mass emissions shall be determined by the following methods: 1) Direct process vent emissions measurements take…

Section 219.503 Performance and Testing Requirements for Batch Operations a) Upon the Agency's request, the owner or operator of a batch operation shall conduct testing to demonstrate compliance with Section 219.501 of this Subpart. The owner or operator shall, at its own expense…

Section 219.504 Monitoring Requirements for Batch Operations a) Every owner or operator using an afterburner to comply with Section 219.501 of this Subpart shall install, calibrate, maintain and operate, according to manufacturer's specifications, temperature monitoring devices w…

Section 219.505 Reporting and Recordkeeping for Batch Operations a) Every owner or operator of a de minimis single unit operation or batch process train exempt under Section 219.500(c)(1) or (c)(2) of this Subpart shall keep records of the uncontrolled total annual mass emissions…

Section 219.506 Compliance Date Every owner or operator of a batch operation subject to Sections 219.500 through 219.506 of this Subpart shall comply with its standards, limitations and mandates by March 15, 1996, or upon initial start up, whichever is later. (Source: Added at 19…

Section 219.520 Emission Limitations for Air Oxidation Processes a) No person shall cause or allow the emission of volatile organic material (VOM) from any process vent stream unless the process vent stream is vented to a combustion device which is designed and operated either: 1…

Section 219.521 Definitions (Repealed) (Source: Repealed at 17 Ill. Reg. 16918, effective September 27, 1993)

Section 219.522 Savings Clause The owner or operator of an air oxidation process with a TRE of 1.0 or less shall have complied with the requirements of Section 219.520(a) of this Subpart by the dates set forth in Section 219.106(a) and (b) of this Part. Sources that are subject t…

Section 219.523 Compliance The emissions limitations for air oxidation processes located in Section 219.520 (a) of this Subpart are applicable to air oxidation processes on October 25, 1994. a) An owner or operator of an air oxidation process with a TRE of 6.0 or less that is sub…

Section 219.524 Determination of Applicability a) Sources subject to the requirements of Section 219.520(a) of this Subpart either through application of 219.520(c) of this Subpart or through continued application under 219.522 of this Subpart shall continue to be subject to the …

Section 219.525 Emission Limitations for Air Oxidation Processes (Renumbered) (Source: Section 219.525 renumbered to Section 219.520 at 18 Ill. Reg. 16980, effective November 15, 1994)

Section 219.526 Testing and Monitoring a) Upon reasonable request by the Agency, the owner or operator of an air oxidation process shall demonstrate compliance with this Subpart by use of the methods specified in Appendix C. This Section does not limit the USEPA's authority, unde…

Section 219.527 Compliance Date (Repealed) (Source: Repealed at 17 Ill. Reg. 16918, effective September 27, 1993) SUBPART W: AGRICULTURE

Section 219.541 Pesticide Exception The provisions of Sections 219.301 and 219.302 of this Part shall not apply to the spraying or use of insecticides, herbicides or other pesticides. (Source: Amended at 17 Ill. Reg. 16918, effective September 27, 1993) SUBPART X: CONSTRUCTION

Section 219.561 Architectural Coatings No person shall cause or allow the sale or use of any architectural coating containing more than 20 percent by volume of photo-chemically reactive material in containers having a capacity of more than one gallon.

Section 219.562 Paving Operations The provisions of Sections 219.301 and 219.302 of this Part shall not apply to the application of paving asphalt and pavement marking paint from sunrise to sunset. (Source: Amended at 17 Ill. Reg. 16918, effective September 27, 1993)

Section 219.563 Cutback Asphalt a) No person shall cause or allow the use or application of cutback asphalt for paving, resurfacing, reconditioning, repairing or otherwise maintaining a roadway unless: 1) The use or application of the cutback asphalt commences on or after October…

Section 219.581 Bulk Gasoline Plants a) Subject to subsection (e) of this Section, no person may cause or allow the transfer of gasoline from a delivery vessel into a stationary storage tank located at a bulk gasoline plant unless; 1) The delivery vessel and the stationary storag…

Section 219.582 Bulk Gasoline Terminals a) No person shall cause or allow the transfer of gasoline into any delivery vessel from any bulk gasoline terminal unless: 1) The bulk gasoline terminal is equipped with a vapor control system that limits emission of VOM to 80 mg/1 (0.0006…

Section 219.583 Gasoline Dispensing Operations – Storage Tank Filling Operations a) Subject to subsection (b) below, no person shall cause or allow the transfer of gasoline from any delivery vessel into any stationary storage tank at a gasoline dispensing operation unless: 1) The…

Section 219.584 Gasoline Delivery Vessels a) Any delivery vessel equipped for vapor control by use of vapor collection equipment: 1) Shall have a vapor space connection that is equipped with fittings which are vapor tight; 2) Shall have its hatches closed at all times during load…

Section 219.585 Gasoline Volatility Standards (Repealed) (Source: Repealed at 37 Ill. Reg. 1722, effective January 28, 2013)

Section 219.586 Gasoline Dispensing Operations - Motor Vehicle Fueling Operations (Repealed) (Source: Repealed at 18 Ill. Reg. 4242, effective March 3, 1994) SUBPART Z: DRY CLEANERS

Section 219.601 Perchloroethylene Dry Cleaners (Repealed) (Source: Repealed at 30 Ill. Reg. 9799, effective May 15, 2006)

Section 219.602 Exemptions (Repealed) (Source: Repealed at 30 Ill. Reg. 9799, effective May 15, 2006)

Section 219.603 Leaks (Repealed) (Source: Repealed at 30 Ill. Reg. 9799, effective May 15, 2006)

Section 219.604 Compliance Dates (Repealed) (Source: Repealed at 17 Ill. Reg. 16918, effective September 27, 1993)

Section 219.605 Compliance Plan (Repealed) (Source: Repealed at 17 Ill. Reg. 16918, effective September 27, 1993)

Section 219.606 Exception to Compliance Plan (Repealed) (Source: Repealed at 17 Ill. Reg. 16918, effective September 27, 1993)

Section 219.607 Standards for Petroleum Solvent Dry Cleaners a) The owner or operator of a petroleum solvent dry cleaning dryer shall either: 1) Limit emissions of volatile organic material to the atmosphere to an average of 3.5 kilograms of VOM per 100 kilograms dry weight of ar…

Section 219.608 Operating Practices for Petroleum Solvent Dry Cleaners In order to minimize fugitive solvent emissions, the owner or operator of a petroleum solvent dry cleaning source shall employ good housekeeping practices including the following: a) General Housekeeping Requi…